Foamed cement composite board, also known as space board, is composed of cold-formed thin-walled steel (or prestressed concrete) frame steel truss, foam cement core material, upper and lower cement surface layers (including fiberglass mesh). Through multiple structural static loads, insulation, sound insulation, fire resistance, water resistance, and other experiments, it has been shown that the stiffness, strength, and other performance of the board meet the relevant national technical specifications.

太空板具有較好的環保節能耐火耐久耐水輕質高強等綜合性能。太空屋面板及墻板在工業與民用建筑中已應用了200余萬平方米，太空板既保持了傳統混凝土制品良好的耐久性能好的特點，在一定程度上彌補了傳統混凝土板自重大，輕質壓型鋼板耐久防水等方面還存在的不足。

The space board has good comprehensive performance such as environmental protection, energy conservation, fire resistance, durability, water resistance, lightweight, and high strength. Space roof panels and wall panels have been applied to over 2 million square meters in industrial and civil buildings. Space panels not only maintain the good durability characteristics of traditional concrete products, but also make up for the shortcomings of traditional concrete panels in terms of self weight and lightweight profiled steel plate durability and waterproofing.

發泡水泥復合板

Foam cement composite board

發泡水泥復合板屋面均可設鋼天溝或混凝土天溝，屋面板兼做天溝板時，板面應按0.5%縱向找坡，雨水斗及雨水管間距應按匯水面積及不同地區降雨強度要求計算確定，發泡水泥復合板上所有洞口均應在板制作時預留特殊需要現場開洞時，應由廠家配合完成。

Steel or concrete gutters can be installed on the roof of the foam cement composite board. When the roof panel is also used as a gutter board, the board surface should be sloped longitudinally at a rate of 0.5%. The spacing between rainwater buckets and rainwater pipes should be calculated and determined based on the catchment area and the rainfall intensity requirements of different regions. All openings on the foam cement composite board should be reserved for special needs during board production. When on-site openings are needed, they should be completed with the cooperation of the manufacturer.

抗震

anti-seismic

抗震設防烈度小于或等于8度的工業和民用建筑，若地震發生時板材造成的次生傷害小，是震區建筑理想的構件材料。

Industrial and civil buildings with seismic fortification intensity less than or equal to 8 degrees are ideal component materials for buildings in seismic areas if the secondary damage caused by the board during an earthquake is minimal.

耐火

refractory

芯板采用無機材質，不燃燒，且在火中不爆裂無有毒氣體釋放，是優良的耐火材料，整板耐火出色大于2小時滿足構件的一級防火要求。

The core board is made of inorganic material, which is non combustible and does not burst or release toxic gases in fire. It is an excellent refractory material, and the fire resistance limit of the entire board is greater than 2 hours, meeting the first level fire protection requirements of the components.

泄爆

Venting explosion

能瞞滿足特殊建筑屋面墻面泄爆易碎的要求。實驗證明，爆炸中發泡水泥復合板鋼骨架將保留在建筑主體結構上，而芯材瞬間粉碎，既達到泄爆目的又不會造成次生傷害。

Be able to meet the requirements for explosive and fragile roof and wall surfaces in special buildings. Experiments have shown that the steel skeleton of the foam cement composite board will remain on the main structure of the building during the explosion, while the core material will be instantly crushed, achieving the purpose of venting the explosion without causing secondary damage.

保溫隔熱

Thermal insulation

板材具有優良的保溫性能，材料導熱系數低，整板傳熱系數低可達0.3W/m2k，滿足高寒地區的建筑保溫節能要求，板材具有優異的隔熱性能，板外側升溫至900℃時，板內側溫度僅為50℃，是高寒地區理想的建筑隔熱材料。

The board has excellent thermal insulation performance, low thermal conductivity of the material, and the minimum heat transfer coefficient of the whole board can reach 0.3W/m2k, which meets the requirements of building thermal insulation and energy conservation in cold regions. The board has excellent thermal insulation performance. When the outside of the board is heated to 900 ℃, the temperature of the inside of the board is only 50 ℃, which is an ideal building thermal insulation material in cold regions.

防水

waterproof

發泡水泥復合板出廠時自帶專用的無機復合抗滲涂層，配合我們整體防水做法形成了可靠的復合防水體系，解決了一般輕質板材易滲漏的問題。

When the foam cement composite board leaves the factory, it comes with a dedicated inorganic composite impermeable coating, which, in conjunction with our overall waterproofing practice, forms a reliable composite waterproofing system, solving the problem of leakage in general lightweight boards.

節能環保

Energy conservation and environmental protection

發泡水泥復合板主要材料均為無機材質，不釋放有毒有害物質，且板材透氣性好，居住健康舒適，發泡水泥復合板成產中可利用部分工業廢料，屬于資源綜合利用產品。

The main materials of foam cement composite board are inorganic materials, which do not release toxic and harmful substances. The board has good breathability, healthy and comfortable living, and some industrial waste can be utilized in the production of foam cement composite board, which belongs to the product of comprehensive resource utilization.

維護簡單

Easy maintenance

發泡水泥復合板正常使用中無需非常維護，使用成本低，局部損壞可以現場直接修復，如有更換必要時，亦可單板更換，不影響整體結構。

The foam cement composite board does not require special maintenance during normal use and has low usage cost. Local damage can be directly repaired on site. If necessary, it can also be replaced with a single board without affecting the overall structure.

本文來自:濟南泡沫復合板更多的內容請點擊: http://m.liondatech.com 我們將會為您提問的問題提供一個滿意的服務，歡迎您的來電！

This article is from: foam composite board in Jinan. For more information, please click: http://m.liondatech.com We will provide a satisfactory service for the questions you ask. Welcome to call us!